Don’t fold the cover on the patch, allow it to lay flat.įor safety pool covers, if the repair is too much for a shade tree pool cover repair – you can send it off to the manufacturer – but you may have to contact the dealer whom you purchased the cover from and have them get a PO number for your cover. Place something heavy on the patch for 6-12 hours before folding.Patch on both sides for extra durability.Cut patches to create rounded corners, or oval patches.To make a good cover repair, here are some tips: Straps can be replaced with nylon webbing (strapping) available at a fabric store, and stitched in place with an awl. Apply the glue to a patch on both sides and press together with something heavy until dry. You can also use rubber cement and pieces of the mesh or solid safety cover material. Just peel and stick, for pool cover repairs up to 8″ long, or link them together for longer tears. We carry an aluminum reinforced PE tape that is waterproof and very sticky – we call it our winter cover patch kit, what else? Other tapes that could be used include Nashua 361-11 Waterproofing Tape and 3M 6969 industrial tape.įor safety pool covers, the type that anchor into the deck, we carry an appropriately named safety cover patch kit. Polyethylene tapes are best, to match the pool cover material stay away from cloth tapes, like Gorilla Tape. Cover Repair Materialsįor solid pool covers, the type that float on the pool water, you want to use a thick tape that is moisture resistant. Even such major damage could still be a candidate for repair by the factory, or local pool cover repair company, if the cover still has a lot of life left in it. Safety covers may lose their straps along one side of the pool, like the picture above, or have damaged several panels. But, if you’ve got a rip along one whole side of the cover, or if the tear is long and curved, then repairing the pool cover may be impossible, or with little chance of success, like the picture shown right. Extent of Pool Cover DamageĪny small rip or tear in a pool cover under 6″ in length is a pretty easy repair. But again, it doesn’t cover tree branches or snow loads, which tend to cause the most damage with punctured material or broken straps. Safety covers typically have a 10-12 yr warranty, and can last much longer. But if you have an actual defect in materials or workmanship, by all means contact the dealer you purchased your pool cover from, with your purchase information. Most everything else is either an Act of God, or neglect (not keeping it pumped off and clean). Speaking of warranty, about the only valid warranty claim is a pool cover that has separated along the seam, for floating type pool covers. If your pool cover is only a couple of years old, and shows no other signs of deterioration (other than your current problem), then you may want to consider patching it, especially if it was an expensive cover, with a long warranty.
0 Comments
Leave a Reply. |
AuthorWrite something about yourself. No need to be fancy, just an overview. ArchivesCategories |